Home › Vehicles › Volvo › VN › 2023

2023 Volvo VN

9 open recalls

Read the first one before you drive it again. Every repair below is free.

Key facts

  • Recall repairs are free by law, however old the vehicle is.
  • You don't need to be the original owner to have it fixed.
  • There is no deadline — an open recall stays open until it's repaired.

Open recalls

Source: NHTSA · synced 29 Jul 2026 13:14
Repair when you can Engine and engine cooling

A detached idler gear can damage the engine, resulting in a stall and increasing the risk of a crash or injury.

The idler gear bracket fasteners may have been improperly tightened, allowing the idler gear to detach from the engine.

What to do: Book it in at your next service. There is no deadline and no charge.

Free repair · 102 vehicles affected Read campaign 25V257000 on NHTSA.gov ↗
Ad slot · height reserved before load
Repair when you can Electrical system

Safety systems that depend on the ECU (Automatic Traction Control, ABS, Electronic Stability Control, Active Cruise Control, and Collison Mitigation System) may have diminished or lost functionality, increasing the risk of a crash.

Electrical noise and low signal to the power line carrier may cause the ECU to incorrectly process commands or stop working.

What to do: Book it in at your next service. There is no deadline and no charge.

Free repair · 124,949 vehicles affected Read campaign 24V790000 on NHTSA.gov ↗
Repair when you can Throttle

Sudden unintended acceleration can increase the risk of a crash.

When the Controller Area Network (CAN) communications are interrupted and the vehicle is in limp mode, an incorrect accelerator pedal signal can result in unintended acceleration. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 124, "Accelerator Control Systems."

What to do: Book it in at your next service. There is no deadline and no charge.

Free repair · 2,098 vehicles affected Read campaign 24V741000 on NHTSA.gov ↗
Repair when you can Vehicle speed control

An engine that does not return to idle quickly enough can cause a loss of vehicle control, increasing the risk of a crash.

The engine may not return to idle within 2 seconds if the accelerator pedal position sensor becomes disconnected. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 124, "Accelerator Control Systems."

What to do: Book it in at your next service. There is no deadline and no charge.

Free repair · 858 vehicles affected Read campaign 23V793000 on NHTSA.gov ↗
Repair when you can Seats

The attachment points may fail, allowing the bench seat to shift and increasing the risk of injury during a crash.

The passenger side bench seat may be inadequately attached to the floor. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 207, "Seating Systems" and 210, "Seatbelt Assembly Anchorage."

What to do: Book it in at your next service. There is no deadline and no charge.

Free repair · 638 vehicles affected Read campaign 23V769000 on NHTSA.gov ↗
Repair soon Steering

Loose steering gear fasteners may result in a loss of vehicle control, increasing the risk of a crash.

The steering gear fasteners may not be properly tightened.

What to do: Book this in with a dealer now. It affects a safety system.

Free repair · 224 vehicles affected Read campaign 23V441000 on NHTSA.gov ↗
Repair when you can Engine and engine cooling

An unexpected engine stall can increase the risk of a crash.

The engine control module (ECM) may experience an internal electrical short-circuit, causing the engine to stall.

What to do: Book it in at your next service. There is no deadline and no charge.

Free repair · 12 vehicles affected Read campaign 22V605000 on NHTSA.gov ↗
Repair soon Steering

A fractured steering gear can cause a loss of steering control, increasing the risk of a crash.

The steering gears may have been assembled incorrectly, which can cause the gear to fracture.

What to do: Book this in with a dealer now. It affects a safety system.

Free repair · 1,779 vehicles affected Read campaign 22V399000 on NHTSA.gov ↗
Repair when you can Structure

Improperly secured cabinets can detach during a crash, increasing the risk of injury.

The cabinets may be improperly secured to the walls due to the bolts being installed without the required washers.

What to do: Book it in at your next service. There is no deadline and no charge.

Free repair · 209 vehicles affected Read campaign 22V115000 on NHTSA.gov ↗

See every model year of the Volvo VN →

Check your exact VIN →

Watch this for new recalls

One email per recall. Nothing else, ever.